G2T60 MEDICAL SERIES SINGLE OUTPUT POWER SUPPLY Low Power Medical Power Supplies 60 Watt AC/DC Universal Input Power Supply SUMMARY • 100 - 240 Vac nominal input range • Overvoltage and short circuit protection • Approved to UL, CSA and EN Standards • Class I input available (GNT60) The G2T60 Series is a 60 W universal input AC/DC power supply in a very small footprint. With the medical approvals the G2T60 is ideal for a variety of medical device applications including, small single board computers, battery charging, and running small motors, pumps, and solenoids. The series with full approval to EN60601-1 and EN60950-1 Standard, improves design-in time and reduces end system compliance costs. O All specifications are typical at nominal input, full load at 25 C unless otherwise stated SPECIFICATIONS OUPUT SPECIFICATIONS INPUT SPECIFICATIONS Output Power Natural Convection 60 Watts max.(65 W with airflow) Input Voltage range Universal input 100-240 nom (85 - 264 max) Vac Total Regulation See table Input frequency 55 Hz +/- 10 Hz Rise time At turn-on 2.0 s max. Input surge current Thermistor limited 37 A max. Transient response Main output 50% 5% max. dev. 1 ms recovery to 0.2 A/ms 1% Ground Leakage current 132 Vac 60 Hz 100 mA Input to grounded- output Temperature Coef- +/-0.03%/oC ficient Input current 120 Vac 1.2 A Overvoltage protection 125% +/-10% 230 Vac 0.7 A Short Circuit protection Power cycling Yes Input fuse F1,F2 3.15 A EMC INFORMATION ENVIRONMENTAL SPECIFICATIONS o RF emissions EN55011 Conducted Class B Thermal Performance operating ambient 0-70 C Radiated Class A (see ratings chart) o non-operating -40 to +85 C Line freq. harmonics EN61000-3-2 Complies o Voltage fluctuations EN61000-3-3 Complies 0 - 50 C 60 Watts Convection cooled ESD EN61000-4-2 Contact 6 kV o Air 8 kV 50 -70 C ambient derate to 50% Convection cooled Radiated immunity EN61000-4-3 3 V/m Relative Humidity non-condensing 5% - 95% RH Fast Transients (EFT) EN61000-4-4 2 kV Maximum Altitude operating / non-operating 10,000 ft. / 40,000 Line surge immunity EN61000-4-5 DIfferential 1 kV ft. max. Common 2 kV Vibration 5 Hz- 500 Hz 2.5 g rms Conducted immunity EN61000-4-6 3 Vrms Shock per MIL-STD-810E 516.4 part IV Power freq. mag. field EN61000-4-8 3 A/m Voltage dip immunity EN61000-4-11 95% dip, 0.5 cycle 60% dip, 5 cycles 30% dip, 25 cycles Note: Voltage dip immunity at 100 V is done with a 20% load GENERAL SPECIFICATIONS Hold-up time 120 Vac, 60 Hz 16 ms at 60 Watts output Efficiency 120 Vac 60 W output >80 % isolation voltage input to ouput 4000 Vac 1500 Vac Switching frequency fixed 60 KHz, +/- 5 KHz Safety Approvals UL/EN/IEC 60601-1 CSA22.2 No.601 UL/EN/IEC 60950-1 CSA22.2 No.60950-1 Maximum weight 140 g (0.29 lbs) o o o MODEL NUMBER 40 C Convection 50 C Convection 50 C Airflow RIPPLE REGULATION G2T60-12 12 V 4.2 A 12 V 3.35 A 12 V 5.0 A 120 mV 2% G2T60-15 15 V 4.0 A 15 V 3.7 A 15 V 4.35 A 150 mV 2% G2T60-24 24 V 2.1 A 24 V 1.9 A 24 V 2.7 A 240 mV 2% NOTES o 1. Convection cooling rating is 40 Watts worst case (G2T60-12 @ 50 C) o o 2. When the input voltage is less than 90 Vac the operating temperature range is 0 C to 40 C. The ripple and regulation specs. may not be met. 3. Peak output rating is 70 Watts for 1 minute. 4. Noise 0.5% RMS, 1% Pk-Pk, 20 MHz Bandwidth, differential mode. Measured with scope probe directly across output terminals of the power supply. o 5. Heatsink temperatures should not be allowed to exceed 90 C 6. Installation data is online at www.condorpower.com MECHANICAL NOTES INPUT J1 AMP P/N 640445-2 TB1 PIN 1 AC LINE PIN 1 AC LINE PIN 2 AC NEUTRAL PIN 2 AC NEUTRAL OUTPUT J2 AMP P/N 640445-4 TB2 PIN 1 OUTPUT 1 PIN 1 COMMON PIN 2 OUTPUT 1 PIN 2 OUTPUT 1 PIN 3 COMMON PIN 4 COMMON MATING CONNECTOR (TYCO/AMP) INPUT HOUSING 640250-2 CONTACT 640706-1 OUTPUT HOUSING 640250-4 CONTACT 640706-1 Condor DC Power Supplies Inc. 2311 Statham Parkway, Oxnard CA, 93033, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 Email: condor@condordc.com G2T60 Rev C 7/27/05. Data Sheet © 2005 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication. However, Condor accepts no responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.