GNT30 MEDICAL SERIES SINGLE OUTPUT POWER SUPPLY Low Power Medical Power Supplies 30 Watt AC/DC Universal Input Power Supply SUMMARY • 90-264 Vac input range • Overvoltage and short circuit protection • Approved to UL, CSA and EN Standards • Small 50 mm x 80 mm footprint • Class II input available (G2T30) The GNT30 Series is a 30 W universal input AC/DC Power supply in a very small footprint. With the medical approvals the GNT30 is ideal for a variety of medical device applications including, small single board computers, battery charging, and running small motors, pumps, and solenoids. The series with full approval to EN60601-1 Standard improves design-in time, and reduces end system compliance costs. O All specifications are typical at nominal input, full load at 25 C unless otherwise stated SPECIFICATIONS OUPUT SPECIFICATIONS INPUT SPECIFICATIONS Output Power 150 l.f.m. airflow 30 Watts max.(See note 4 Input Voltage range Universal input 100-240 nom (90 - 264 max) Vac Total Regulation See table Input frequency 55 Hz +/- 10 Hz Turn-on time 1.5 s max. Input surge current 32 A max. Transient response 0.25 A/ms 50% load 3.5% max. dev. 1 ms recovery deviation to 1% Ground Leakage current 132 Vac 60 Hz 100 mA (180 mA single fault) Temperature Coef- +/-0.03%/oC Input current 120 Vac 0.6 A ficient 230 Vac 0.37 A Overvoltage protection 125% +/-10% Input fuse F1,F2 2.5 A Short Circuit protection Power cycling Yes EMC INFORMATION ENVIRONMENTAL SPECIFICATIONS o Conducted emissions EN55011 Level B Thermal Performance operating ambient 0-50 C (see chart) Radiated emissions EN55011 Level A o non-operating -40 to +85 C Line freq. harmonics EN61000-3-2 Complies o 0 - 50 C 30 Watts Voltage fluctuations EN61000-3-3 Complies 150 l.f.m (See note 4.) ESD Air EN61000-4-2 8 kV contact o o 50 -70 C ambient derate 2% / C ESD Contact EN61000-4-2 6 kV air 150 l.f.m Relative Humidity non-condensing 0% - 95% RH Radiated immunity EN61000-4-3 3 V/m Maximum Altitude operating / non-operating 10,000 ft. / 40,000 ft. max. Fast Transients (EFT) EN61000-4-4 2 kV Vibration Operating 1.5 g 20-2000 Hz rms Line surge immunity EN61000-4-5 1 kV diff /2 kV cm Non-operating 5 g 20-2000 Hz rms Conducted immunity EN61000-4-6 3 V rms Shock Operating 20 g 10 ms, half-sine pk Power freq. mag. field EN61000-4-8 3 A/m Non-operating 40 g 10 ms half-sine pk Voltage dip immunity EN61000-4-11 5 cycles 40 % vnom 0.5 Watts. 25 cycles 70 % vnom 20 W GENERAL SPECIFICATIONS Hold-up time 120 Vac, 60 Hz 16 ms at 30 Watts output Efficiency 120 Vac 30 W output >78 % isolation voltage input to ouput 4000 Vac input to ground 1500 Vac Switching frequency fixed 120 KHz, +/- 5 KHz Safety Approvals UL/EN/IEC 60601-1 CSA22.2 No.601 UL/EN/IEC 60950-1 CSA22.2 No.60950-1 Maximum weight 100 g (0.22 lbs) o o o MODEL NUMBER 40 C Convection 50 C Convection 50 C Airflow RIPPLE REGULATION GNT30-5 5 V 4.0 A 5 V 3.2 A 5 V 6.0 A 50 mV 2% GNT30-12 12 V 2.5 A 12 V 1.66 A 12 V 2.5 A 120 mV 2% GNT30-15 15 V 2.0 A 15 V 1.06 A 15 V 2.0 A 150 mV 2% GNT30-24 24 V 1.25 A 24 V 0.83 A 24 V 1.25 A 240 mV 2% GNT30-28 28 V 1.07 A 28 V 0.8 A 28 V 1.07 A 280 mV 2% GNT30-48 48 V 0.625 A 48 V 0.416 A 48 V 0.625 A 480 mV 2% NOTES o o 1. When the input voltage is less than 90 Vac the operating temperature range is 0 C to 40 C. The ripple and regulation specs. may not be met. 2. Peak output current rating is for 1 minute and 10 % duty cycle. o 3. Heatsink temperatures should not be allowed to exceed 90 C 4. Output Voltage is adjustable +/- 5% of nominal. See installation instructions (www.condorpower.com) MECHANICAL NOTES INPUT J1 AMP P/N 640456-3 TB1 PIN 1 AC LINE PIN 1 AC LINE PIN 2 N/C PIN 2 AC NEUTRAL PIN 3 AC NEUTRAL 0.187 Faston GROUND GROUND OUTPUT J2 AMP P/N 640456-4 TB2 PIN 1 COMMON PIN 1 COMMON PIN 2 COMMON PIN 2 OUTPUT 1 PIN 3 OUTPUT 1 PIN 4 OUTPUT 1 MATING CONNECTORS CONTACT INPUT HOUSING 1375820-3 1375819-1 OUTPUT HOUSING 1375820-4 1375819-1 Condor DC Power Supplies Inc. 2311 Statham Parkway, Oxnard CA, 93033, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 Email: condor@condordc.com GNT30 Rev H 11/11/05. Data Sheet © 2005 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication. However, Condor accepts no responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.