GNT60 MEDICAL SERIES SINGLE OUTPUT POWER SUPPLY Low Power Medical Power Supplies 65 Watt AC/DC Universal Input Power Supply Summary: • 100 - 240 Vac nominal input range • Overvoltage and short circuit protection D C P o w e r S u p p l i e s • Approved to UL, CSA and EN Standards • Class II input available (G2T60) • RoHS Compliant Model Available (G suffix) The GNT60 Series is a 65 W universal input AC/DC power supply in a very small footprint. With the medical approvals the GNT60 is ideal for a variety of medical device applications including small single board computers, battery charging, running small motors, pumps, and solenoids. The series, with approval to 60601-1 and 60950 standards, improves design-in time and reduces end system compliance costs. Specifications: OUPUT SPECIFICATIONS INPUT SPECIFICATIONS Output Power Natural Convec- 60 Watts max.(65 W with airflow) Input Voltage range Universal input 100-240 nom (85 - 264 max) Vac tion See table Input frequency 55 Hz +/- 10 Hz Total Regulation See table Input surge current Thermistor 37 A max. limited Rise time At turn-on 2.0 s max. Ground Leakage 264 Vac 60 Hz 300 μA max. (400 μA single fault) Transient response Main output 50% 3.55% max. dev. 1 μs recovery current 0.2 A/μs to 0.5% Input current 120 Vac 1.2 A Temperature +/-0.03%/oC Coefficient 230 Vac 0.7 A Overvoltage 108% to 130% Input fuse F1,F2 3.15 A protection Short Circuit Cycling/foldback Yes protection EMC INFORMATION ENVIRONMENTAL SPECIFICATIONS o Conducted emissions EN55011 Level B Thermal Performance operating ambient 0-70 C (see ratings chart) Radiated emissions EN55011 Level A o non-operating -40 to +85 C Line freq. harmonics EN61000-3-2 Complies o 0 - 50 C Full load. See table. Voltage fluctuations EN61000-3-3 Complies ESD Air EN61000-4-2 8 kV contact o 50 -70 C ambient derate to 50% ESD Contact EN61000-4-2 6 kV air Relative Humidity non-condensing 5% - 95% RH Radiated immunity EN61000-4-3 3 V/m Maximum Altitude operating / non-operating 10,000 ft. / 40,000 ft. max. Fast Transients (EFT) EN61000-4-4 2 kV Vibration 5 Hz- 500 Hz 2.5 g rms Line surge immunity EN61000-4-5 1 kV diff /2 kV cm Shock per MIL-STD-810E 516.4 part IV Conducted immunity EN61000-4-6 3 Vrms Power freq. mag. field EN61000-4-8 3 A/m Voltage dip immunity EN61000-4-11 5 cycles 40 % Vnom 22% load 100 Vac 25 cycles 70 % Vnom 52% load 0.5 cycles <5% Vnom 88% load O All specifications are typical at nominal input, full load at 25 C unless otherwise stated GENERAL SPECIFICATIONS Hold-up time 120 Vac, 60 Hz 16 ms at 60 Watts output Efficiency 120 Vac 60 W output >80 % Isolation voltage input to ouput 4000 Vac input to ground 1500 Vac Switching frequency fixed 60 KHz, +/- 5 KHz Safety Approvals UL/EN/IEC 60601-1 CSA22.2 No.601, UL/EN/IEC 60950-1 1st Edition, CSA22.2 No.60950-1-03 Maximum weight 140 g (0.29 lbs) o o o MODEL NUMBER 50 C Airflow 65 W (1) 40 C Convection 50 C Convection RIPPLE REGULATION GNT60-12 12 V 5.0 A 12 V 4.2 A 12 V 3.35 A 120 mV 2% GNT60-15 15 V 4.35 A 15 V 4.0 A 15 V 3.7 A 150 mV 2% GNT60-24 24 V 2.7 A 24 V 2.1 A 24 V 1.9 A 240 mV 2% GNT60-48 48 V @ 1.35 A 48 V @ 1.25 A 48 V @ 1.35 A 480 mV 2% NOTES 1. All models 65 W with 100 lfm airflow except GNT60-12 (60 W) o o 2. When the input voltage is less than 90 Vac the operating temperature range is 0 C to 40 C. The ripple and regulation specs. may not be met. 3. Peak output rating is 70 Watts for 1 minute. 4. Noise 0.5% RMS, 1% Pk-Pk, 20 MHz Bandwidth, differential mode. Measured with scope probe directly across output terminals of the power supply. o 5. Heatsink temperatures should not be allowed to exceed 90 C 6. Installation data is online at www.condorpower.com 7. Add “G” suffix to model number for RoHS compliant model. o 8. Convection cooling rating is 40 Watts worst case (GNT60-12 @ 50 C) Mechanical Notes INPUT J1 AMP P/N 640445-2 PIN 1 AC LINE PIN 3 AC NEUTRAL GROUND 0.187 FASTON OUTPUT J2 AMP P/N 640445-4 PIN 1 OUTPUT 1 PIN 2 OUTPUT 1 PIN 3 COMMON PIN 4 COMMON MATING CONNECTOR (TYCO/AMP) INPUT HOUSING 640250-3 CONTACT 640706-1 OUTPUT HOUSING 640250-4 CONTACT 640706-1 SL Power Electronics Corp., 6050 King Drive, Bldg. A, Ventura, CA 93003, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 www.slpower.com. GNT60 Rev 4/7/10. Data Sheet © 2010 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication. However, SL Power accepts no responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.